威格士柱塞泵常见故障处理
1.柱塞泵输出流量不足或不输出油液
(1)吸入量不足。原因是吸油管路上的阻力过大或补油量不足。如泵的转速过大，油箱中液面过低，进油管漏气，滤油器堵塞等。
(2)泄漏量过大。原因是泵的间隙过大，密封不良造成。如配油盘被金属碎片、铁屑等划伤，端面漏油;变量机构中的单向阀密封面配合不好，泵体和配油盘的支承面有砂眼或研痕等。可以通过检查泵体内液压油中混杂的异物判别泵被损坏的部位。
(3)倾斜盘倾角太小，泵的排量少，这需要调节变量活塞，增加斜盘倾角。
2.中位时排油量不为零 变量式轴向柱塞泵的斜盘倾角为零时称为中位，此时泵的输出流量应为零。但有时会出现中位偏离调整机构中点的现象，在中点时仍有流量输出。其原因是控制器的位置偏离、松动或损伤，需要重新调零、紧固或更换。泵的角度维持力不够、倾斜角耳轴磨损也会产生这种现象。
3.输出流量波动 输出流量波动与很多因素有关。对变量泵可以认为是变量机构的控制不佳造成，如异物进入变量机构，在控制活塞上划出阶痕、磨痕、伤痕等，造成控制活塞运动不稳定。由于放大器能量不足或零件损坏、含有弹簧的控制活塞的阻尼器效能差，都会造成控制活塞运动不稳定。流量不稳定又往往伴随着压力波动。这类故障一般要拆开液压泵，更换受损零部件，加大阻尼，提高弹簧刚度和控制压力等。
4.输出压力异常 泵的输出压力是由负载决定的，与输入转矩近似成正比。输出压力异常有两种故障。
(1)输出压力过低 当泵在自吸状态下，若进油管路漏气或系统中液压缸、单向阀、换向阀等有较大的泄漏，均会使压力升不上去。这需要找出漏气处，紧固、更换密封件，即可提高压力。溢流阀有故障或调整压力低，系统压力也上不去，应重新调整压力或检修溢流阀。如果液压泵的缸体与配流盘产生偏差造成大量泄漏，严重时，缸体可能破裂，则应重新研磨配合面或更换液压泵。
(2)输出压力过高 若回路负载持续上升，泵的压力也持续上升，当属正常。若负载一定，泵的压力超过负载所需压力值，则应检查泵以外的液压元件，如方向阀、压力阀、传动装置和回油管道。若最大压力过高，应调整溢流阀。
5.振动和噪声 振动和噪声是同时出现的。它们不仅对机器的操作者造成危害，也对环境造成污染。
(1)机械振动和噪声 如泵轴和电机轴不同心或顶死，旋转轴的轴承、联轴节损伤，弹性垫破损和装配螺栓松动均会产生噪声。对于高速运转或传输大能量的泵，要定期检查，记录各部件的振幅、频率和噪声。如泵的转动频率与压力阀的固有频率相同时，将会引起共振，可改变泵的转速以消除共振。
(2)管道内液流产生的噪声 进油管道太细、进油滤油器通流能力过小或堵塞、进油管吸入空气、油液豁度过高、油面过低吸油不足和高压管道中产生液击等，均会产生噪声。因此，必须正确设计油箱，正确选择滤油器、油管和方向阀。
6.威格士柱塞泵过热 液压泵过度发热有两个原因，一是机械摩擦生热。由于运动表面处于干摩擦或半干摩擦状态，运动部件相互摩擦生热。二是液体摩擦生热。高压油通过各种缝隙泄漏到低压腔，大量的液压能损失转为热能。所以正确选择运动部件之间的间隙、油箱容积和冷却器，可以杜绝泵的过度发热和油温过高的现象。另外，回油过滤器堵塞造成回油背压过高，也会引起油温过高和泵体过热。
7.漏油 柱塞泵漏油主要有以下原因:(1)主轴油封损坏或轴有缺陷、划痕;(2)内部泄漏过大，造成油封处压力增大，而将油封损伤或冲出;(3)泄油管过细过长，使密封处漏油;(4)泵的外接油管松动，管接头损伤，密封垫老化或产生裂纹;(5)变量调节机构螺栓松动，密封破损;(6)铸铁泵壳有砂眼或焊接不良。
PVE19-B2R-STS1F-41-C21D-12
PVE19AR05AA10B312600A100100CD0A
PVE19-B2R-STS9F-41-C24VPC26B-13-158
PVE19AR05AA10B211100A100100CD0A
PVE19-B2R-STS9F-41-C21VP11B-13
PVE19AL05AA10B211100A100100CD0A
PVE19AR02AA10B211100A100100CD0A
PVE19-B2R-STS1F-41-C21VP11B-13
PVE19AL02AA10B211100A100100CD0A
PVE19-B2L-STS1F-41-C21VP11B-13
PVE19AL08AA10B211100A100100CD0A
PVE19-B2L-STS2F-41-C21VP11B-13
PVE19AR08AA10B211100A100100CD0A
PVE19-B2R-STS2F-41-C21VP11B-13
PVE19AR05AA10B212400A100100CD0A
PVE19-B2R-STS9F-41-C21VPC24B-13-CD
PVE19AL05AA10B212400A100100CD0A
PVE19-B2L-STS9F-41-C21VPC24B-13
PVE19AL08AA10A140000H100100CD0A
PVE19-B2L-STS2F-41-C14-12-061
PVE19AL15AA20A160000F100100CD0A
PVE19-B2L-STS5F-41-C15-12-010
PVE19AR05AB10A2100000200100CD0A
PVE19-B2R-STE9F-41-C21D-12
PVE21AL08AW21B33240001001AHCDAA
PVE21-B2L-MFE2F-41-C21VPC24P-13-317
PVE21AR08AS11B33240001001AHCDAA
PVE21-B2R-MFE2F-41-C21VPC24P-13-316
PVE21AR04AA10A3000000100100CD0A
PVE21-B2R-STS13F-41-C19-12
PVE21AR05AB10B27240001001AGCD0A
PVE21AL05AB10B27240001001AGCD0A
PVE21-B2L-STE9F-41-C20VPC24P-13-295
PVE21AR08AB10B212400A2001AFCD0A
PVE21AL14AA20B21170001001AECC3A
PVE21-B2L-STS30F-41-C21VPC17P-13-263
PVE21AR17AA10A2900000100100CC3A
PVE21-B2R-STS31F-41-C16-12-261
PVE21AR05AA10A1800000200100CD0A
PVE21-B2R-STS9F-41-C19D-12
PVE21AL05AD21E1924000100100CD0A
PVE21AL17AA20B3014000100100CC3A
PVE21AR02AA10A1800000200100CD0A
PVE21-B2R-STS1F-41-C19D-12
PVE21AR17AA10A2800000100100CC3A
PVE21-B2R-STS31F-41-C09-12-240
PVE21AL08AA10H1811000100100CD0A
PVE21-B2L-STS2F-41-C19VP11P-13-234
PVE21AR08AD21B3024000100100CDBA
PVE21-B2R-SFE2F-41-C19VPC24P-13-220
PVE21AL08AT21B3024000100100CDBA
PVE21-B2L-SFE2F-41-C19VPC24P-13-219
PVE21AR08AA10B35160001AG100CD0A
PVE21G-B2R-STS2F-41-C17VP15P-13-204
PVE21AR08AD21B302400A100100CD0A
PVE21AL08AT21B302400A100100CD0A
PVE21-B2L-SFE2F-41-C19VPC24B-13-212
PVE21AL05AB10B181100A100100CD0A
PVE21-B2L-STE9F-41-C19VP11B-13
PVE21AR05AB10B191100A100100CD0A
PVE21-B2R-STE9F-41-C19VP11B-13
PVE21AR05AA10A1800000100100CD0A
PVE21-B2R-STS9F-41-C19-12
PVE21AL05AA10A1800000100100CD0A
PVE21-B2L-STS9F-41-C19-12
PVE21AL08AA10A1800000100100CD0A
PVE21-B2L-STS2F-41-C19-12
PVE21AL02AA10A1800000100100CD0A
PVE21-B2L-STS1F-41-C19-12
PVE21AR02AA10A1800000100100CD0A
PVE21-B2R-STS1F-41-C19-12
PVE21AR08AA10A1800000100100CD0A
PVE21-B2R-STS2F-41-C19-12
PVE21AR08AA10A19000001AE100CD0A
PVE21AL14AA20B18140001001AECC3A
PVE21-B2L-STS30F-41-C19VP14P-13-178
PVE21AR04AA10B3425000100100CD0A
PVE21-B2R-STS13F-41-C17VPC25P-13-134
PVE21AL05AAA0B3825000100000CD0A
PVE21-B2L-STS9N-41-C18VPC25P-13-043
PVE21AR08AB20B351600A100100CDBA
PVE21-B2R-STE2F-41-C17VP15B-13-161
PVE21AR05AA10B191100A100100CD0A
PVE21AL05AA10B191100A100100CD0A
PVE21-B2L-STS9F-41-C19VP11B-13
PVE21AR02AA10B181100A100100CD0A
PVE21-B2R-STS1F-41-C19VP11B-13
PVE21AL02AA10B181100A100100CD0A
PVE21-B2L-STS1F-41-C19VP11B-13
PVE21AL05ARA0B1925000100000CD0A
PVE21-B2L-STE9N-41-C19VPC25P-13-166
PVE21AL08AA10B181100A100100CD0A
PVE21-B2L-STS2F-41-C19VP11B-13
PVE21AR08AA10B181100A100100CD0A
PVE21-B2R-STS2F-41-C19VP11B-13
PVE19AR13AP63B23300001001AD0K5A
PVE19-B2R-MTE9AF-41-C20VPC30P-13-264
PVE21AR08AA10A00CD0A
PVE19AR02AA10A21000001AA1APCD0A
PVE19AR02AC10A21000001AA1APCD0A
PVE19AR08AA10B211100A1AE100CD0A
PVE19AR08AC10B211100A1AB100CD0A
PVE21AR08AB10B00CD0A
PVE19AR05AB10B20CD0A
PVE19AR08AA10D01000001AE100CD0A
PVE19AR01AA10A140000E100100CD0A
PVH98QIC3-RF-1S-11-C25V-31
PVH131L13AJ30A070000002001AE010A
PVH131QIC-LSF-13S-11-CM7-31
PVH131R16AF30E252004001AD1AE010A
PVH131QIC-RAF-16S-11-C25VT4-31
PVH098R02AJ30A250000001AD1AA010A
PVH98C-RAF-2S-11-C25-31-036
PVH074R03AA10B252000001AP1AA010A
PVH74C-RCF-3S-11-C25V-31
PVH131L03AF30E252004001AD1AA010A
PVH131C-LAF-3S-11-C25VT4-31
PVH098R63AJ30E252004001AD1AE010A
PVH98QIC2-RAF-13S-11-C25VT4-31
PVH098L53AJ30E252004001AD1AA010A
PVH98C2-LAF-3S-11-C25VT4-31
PVH074R63AA10E252004001AF1AE010A
PVH74QIC2-RAF-13S-11-C25VT4-31
PVH074L53AA10E252004001AF1AA010A
PVH74C2-LAF-3S-11-C25VT4-31
PVH057L52AA10E252004001AE1AA010A
PVH57C2-LAF-2S-11-C25VT4-31
PVH074R01AA10D250014001001AA010A
PVH74C-RF-1S-11-C25T14-31
PVH098L02AJ30B102000AG1AD1AA010A
PVH98C-LAF-2S-11-C10V-31-036
PVH074L02AA10B122000AG1002AA010A
PVH74C-LF-2D-11-C12V-31
PVH074R02AA10E252014001001AA010A
PVH74C-RF-2S-11-C25VT17-31
PVH074R13AA10A070000001AF1AF010A
PVH74QPC-RAF-13S-11-CM7-31
PVH131R03AF30E252008001AD1AA010A
PVH131C-RAF-3S-11-C25VT8-31
PVH098R13AJ70B252000001AD1AE010A
PVH98QIC3-RAF-13S-11-C25V-31
PVH098R51AD30A070000002001AF010A
PVH98QPC2-RSM-1S-11-CM7-31
PVH098R02AJ30D250004001002AE010A
PVH98QIC-RF-2D-11-C25T4-31
PVH074R01AB10A070000002001AE010A
PVH74QIC-RSM-1S-11-CM7-31
PVH098R13AJ70A250000001AD1AE010A
PVH98QIC3-RAF-13S-11-C25-31
PVH098R03AJ30A250000001AD2AA010A
PVH98C-RAF-3D-11-C25-31
PVH074L02AB10B252000001001AA010A
PVH74C-LM-2S-11-C25V-31
PVH074L02AB10B252000001AF1AA010A
PVH74C-LAM-2S-11-C25V-31-036
PVH074R0NAB10A070000001001AF010A
PVH74QPM-RM-NS-11-CM7-31
PVH074R51AB10A070000002001AE010A
PVH74QIC2-RSM-1S-11-CM7-31
PVH057L52AA10B252000001001AA010A
PVH57C2-LF-2S-11-C25V-31
PVH131L02AF30B252000001002AA010A
PVH131C-LF-2D-11-C25V-31
PVH074R13AA10E252007001AF1AE010A
PVH74QIC-RAF-13S-11-C25VT7-31
PVH057R02AA10E252007001001AE010A
PVH57QIC-RF-2S-11-C25VT7-31
PVH074R01AA10B252000001001AN010A
PVH74C-RF-1S-11-C25V-31-115
PVH098R01AJ30A250000001001AN010A
PVH98C-RF-1S-11-C25-31-115
PVH057R02AA10A150000001AE2AA010A
PVH57C-RAF-2D-11-C15-31
PVH098R01AJ30D250005001001BC010A
PVH98QIC-RF-1S-11-C25T5-31-115
PVH098L02AJ30B102000AG1001AA010A
PVH98C-LF-2S-11-C10V-31
PVH074R02AA10A190000001AP2AA010A
PVH74C-RCF-2D-11-C19-31-036
PVH074R02AA10A190000001002AA010A
PVH74C-RF-2D-11-C19-31
PVH098L02AJ30A100000AG1001AA010A
PVH98C-LF-2S-11-C10-31
PVH074L02AA10A190000001002AA010A
PVH74C-LF-2D-11-C19-31
PVH098R02AJ30A250000001002AA010A
