威格士柱塞泵常见故障处理
1.柱塞泵输出流量不足或不输出油液
(1)吸入量不足。原因是吸油管路上的阻力过大或补油量不足。如泵的转速过大，油箱中液面过低，进油管漏气，滤油器堵塞等。
(2)泄漏量过大。原因是泵的间隙过大，密封不良造成。如配油盘被金属碎片、铁屑等划伤，端面漏油;变量机构中的单向阀密封面配合不好，泵体和配油盘的支承面有砂眼或研痕等。可以通过检查泵体内液压油中混杂的异物判别泵被损坏的部位。
(3)倾斜盘倾角太小，泵的排量少，这需要调节变量活塞，增加斜盘倾角。
2.中位时排油量不为零 变量式轴向柱塞泵的斜盘倾角为零时称为中位，此时泵的输出流量应为零。但有时会出现中位偏离调整机构中点的现象，在中点时仍有流量输出。其原因是控制器的位置偏离、松动或损伤，需要重新调零、紧固或更换。泵的角度维持力不够、倾斜角耳轴磨损也会产生这种现象。
3.输出流量波动 输出流量波动与很多因素有关。对变量泵可以认为是变量机构的控制不佳造成，如异物进入变量机构，在控制活塞上划出阶痕、磨痕、伤痕等，造成控制活塞运动不稳定。由于放大器能量不足或零件损坏、含有弹簧的控制活塞的阻尼器效能差，都会造成控制活塞运动不稳定。流量不稳定又往往伴随着压力波动。这类故障一般要拆开液压泵，更换受损零部件，加大阻尼，提高弹簧刚度和控制压力等。
4.输出压力异常 泵的输出压力是由负载决定的，与输入转矩近似成正比。输出压力异常有两种故障。
(1)输出压力过低 当泵在自吸状态下，若进油管路漏气或系统中液压缸、单向阀、换向阀等有较大的泄漏，均会使压力升不上去。这需要找出漏气处，紧固、更换密封件，即可提高压力。溢流阀有故障或调整压力低，系统压力也上不去，应重新调整压力或检修溢流阀。如果液压泵的缸体与配流盘产生偏差造成大量泄漏，严重时，缸体可能破裂，则应重新研磨配合面或更换液压泵。
(2)输出压力过高 若回路负载持续上升，泵的压力也持续上升，当属正常。若负载一定，泵的压力超过负载所需压力值，则应检查泵以外的液压元件，如方向阀、压力阀、传动装置和回油管道。若最大压力过高，应调整溢流阀。
5.振动和噪声 振动和噪声是同时出现的。它们不仅对机器的操作者造成危害，也对环境造成污染。
(1)机械振动和噪声 如泵轴和电机轴不同心或顶死，旋转轴的轴承、联轴节损伤，弹性垫破损和装配螺栓松动均会产生噪声。对于高速运转或传输大能量的泵，要定期检查，记录各部件的振幅、频率和噪声。如泵的转动频率与压力阀的固有频率相同时，将会引起共振，可改变泵的转速以消除共振。
(2)管道内液流产生的噪声 进油管道太细、进油滤油器通流能力过小或堵塞、进油管吸入空气、油液豁度过高、油面过低吸油不足和高压管道中产生液击等，均会产生噪声。因此，必须正确设计油箱，正确选择滤油器、油管和方向阀。
6.威格士柱塞泵过热 液压泵过度发热有两个原因，一是机械摩擦生热。由于运动表面处于干摩擦或半干摩擦状态，运动部件相互摩擦生热。二是液体摩擦生热。高压油通过各种缝隙泄漏到低压腔，大量的液压能损失转为热能。所以正确选择运动部件之间的间隙、油箱容积和冷却器，可以杜绝泵的过度发热和油温过高的现象。另外，回油过滤器堵塞造成回油背压过高，也会引起油温过高和泵体过热。
7.漏油 柱塞泵漏油主要有以下原因:(1)主轴油封损坏或轴有缺陷、划痕;(2)内部泄漏过大，造成油封处压力增大，而将油封损伤或冲出;(3)泄油管过细过长，使密封处漏油;(4)泵的外接油管松动，管接头损伤，密封垫老化或产生裂纹;(5)变量调节机构螺栓松动，密封破损;(6)铸铁泵壳有砂眼或焊接不良。
PVE19-B2R-STS1F-41-C21D-12
PVE19AR05AA10B312600A100100CD0A
PVE19-B2R-STS9F-41-C24VPC26B-13-158
PVE19AR05AA10B211100A100100CD0A
PVE19-B2R-STS9F-41-C21VP11B-13
PVE19AL05AA10B211100A100100CD0A
PVE19AR02AA10B211100A100100CD0A
PVE19-B2R-STS1F-41-C21VP11B-13
PVE19AL02AA10B211100A100100CD0A
PVE19-B2L-STS1F-41-C21VP11B-13
PVE19AL08AA10B211100A100100CD0A
PVE19-B2L-STS2F-41-C21VP11B-13
PVE19AR08AA10B211100A100100CD0A
PVE19-B2R-STS2F-41-C21VP11B-13
PVE19AR05AA10B212400A100100CD0A
PVE19-B2R-STS9F-41-C21VPC24B-13-CD
PVE19AL05AA10B212400A100100CD0A
PVE19-B2L-STS9F-41-C21VPC24B-13
PVE19AL08AA10A140000H100100CD0A
PVE19-B2L-STS2F-41-C14-12-061
PVE19AL15AA20A160000F100100CD0A
PVE19-B2L-STS5F-41-C15-12-010
PVE19AR05AB10A2100000200100CD0A
PVE19-B2R-STE9F-41-C21D-12
PVE21AL08AW21B33240001001AHCDAA
PVE21-B2L-MFE2F-41-C21VPC24P-13-317
PVE21AR08AS11B33240001001AHCDAA
PVE21-B2R-MFE2F-41-C21VPC24P-13-316
PVE21AR04AA10A3000000100100CD0A
PVE21-B2R-STS13F-41-C19-12
PVE21AR05AB10B27240001001AGCD0A
PVE21AL05AB10B27240001001AGCD0A
PVE21-B2L-STE9F-41-C20VPC24P-13-295
PVE21AR08AB10B212400A2001AFCD0A
PVE21AL14AA20B21170001001AECC3A
PVE21-B2L-STS30F-41-C21VPC17P-13-263
PVE21AR17AA10A2900000100100CC3A
PVE21-B2R-STS31F-41-C16-12-261
PVE21AR05AA10A1800000200100CD0A
PVE21-B2R-STS9F-41-C19D-12
PVE21AL05AD21E1924000100100CD0A
PVE21AL17AA20B3014000100100CC3A
PVE21AR02AA10A1800000200100CD0A
PVE21-B2R-STS1F-41-C19D-12
PVE21AR17AA10A2800000100100CC3A
PVE21-B2R-STS31F-41-C09-12-240
PVE21AL08AA10H1811000100100CD0A
PVE21-B2L-STS2F-41-C19VP11P-13-234
PVE21AR08AD21B3024000100100CDBA
PVE21-B2R-SFE2F-41-C19VPC24P-13-220
PVE21AL08AT21B3024000100100CDBA
4520V42A5 1CC22R
4520V42A11 1AB22R
4520V42A11 1AC22R
4520V42A12 1CC22R
4520V42A12 86DD22R
4520V50A5 1CC22R
4520V50A8 1CC22R
4520V50A11 1AA22R
4520V50A11 1CC22R
4520V50A12 1AA22R
4520V50A14-1AA22L
4520V60A5 1CC22R
4520V60A8 1AA22R
4520V60A8 1CC22R
4520V60A11 1AD22R
4520V60A12 1AA22R
4520V60A12 1CC22R
4520V60A14 1CC22R
4520VQ42A5 1CC22R
4520VQ42A11 1AB22R
4520VQ42A12 86DD22R
4520VQ50A5 1CC22R
4520VQ50A8 1CC22R
4520VQ50A11 1AA22R
4520VQ50A11 1CC22R
4520VQ50A12 1AA22R
4520VQ50A14-1AA22L
4520VQ60A5 1CC22R
4520VQ60A8 1AA22R
4520VQ60A8 1CC22R
4520VQ60A11 1AD22R
4520VQ60A12 1AA22R
4520VQ60A12 1CC22R
4520VQ60A14 1CC22R
4520V42A5-1CC22R
4520V42A11-1AB22R
4520V42A11-1AC22R
4520V42A12-1CC22R
4520V42A12-86DD22R
4520V50A5-1CC22R
4520V50A8-1CC22R
4520V50A11-1AA22R
4520V50A11-1CC22R
4520V50A12-1AA22R
4520V60A5-1CC22R
4520V60A8-1AA22R
4520V60A8-1CC22R
4520V60A11-1AD22R
4520V60A12-1AA22R
4520V60A12-1CC22R
4520V60A14-1CC22R
4520VQ60A8 86DD20
4520VQ60A8 86AA20
4520VQ60A8 11CC20
4520VQ60A12 11CC20
4520VQ60A11 86CC20
4520VQ50A8 86AA20
4520VQ50A11 11CC20
4520VQ42A8 11CC20
4520VQ42A11 1DC20
PVE19AR08AA10D01000001AE100CD0A
PVE19AR01AA10A140000E100100CD0A
PVH98QIC3-RF-1S-11-C25V-31
PVH131L13AJ30A070000002001AE010A
PVH131QIC-LSF-13S-11-CM7-31
PVH131R16AF30E252004001AD1AE010A
PVH131QIC-RAF-16S-11-C25VT4-31
PVH098R02AJ30A250000001AD1AA010A
PVH98C-RAF-2S-11-C25-31-036
PVH074R03AA10B252000001AP1AA010A
PVH74C-RCF-3S-11-C25V-31
PVH131L03AF30E252004001AD1AA010A
PVH131C-LAF-3S-11-C25VT4-31
PVH098R63AJ30E252004001AD1AE010A
PVH98QIC2-RAF-13S-11-C25VT4-31
PVH098L53AJ30E252004001AD1AA010A
PVH98C2-LAF-3S-11-C25VT4-31
PVH074R63AA10E252004001AF1AE010A
PVH74QIC2-RAF-13S-11-C25VT4-31
PVH074L53AA10E252004001AF1AA010A
PVH74C2-LAF-3S-11-C25VT4-31
PVH057L52AA10E252004001AE1AA010A
PVH57C2-LAF-2S-11-C25VT4-31
PVH074R01AA10D250014001001AA010A
PVH74C-RF-1S-11-C25T14-31
PVH098L02AJ30B102000AG1AD1AA010A
PVH98C-LAF-2S-11-C10V-31-036
PVH074L02AA10B122000AG1002AA010A
PVH74C-LF-2D-11-C12V-31
PVH074R02AA10E252014001001AA010A
PVH74C-RF-2S-11-C25VT17-31
PVH074R13AA10A070000001AF1AF010A
PVH74QPC-RAF-13S-11-CM7-31
PVH131R03AF30E252008001AD1AA010A
PVH131C-RAF-3S-11-C25VT8-31
PVH098R13AJ70B252000001AD1AE010A
PVH98QIC3-RAF-13S-11-C25V-31
PVH098R51AD30A070000002001AF010A
PVH98QPC2-RSM-1S-11-CM7-31
PVH098R02AJ30D250004001002AE010A
PVH98QIC-RF-2D-11-C25T4-31
PVH074R01AB10A070000002001AE010A
PVH74QIC-RSM-1S-11-CM7-31
PVH098R13AJ70A250000001AD1AE010A
PVH98QIC3-RAF-13S-11-C25-31
PVH098R03AJ30A250000001AD2AA010A
PVH98C-RAF-3D-11-C25-31
PVH074L02AB10B252000001001AA010A
PVH74C-LM-2S-11-C25V-31
PVH074L02AB10B252000001AF1AA010A
PVH74C-LAM-2S-11-C25V-31-036
PVH074R0NAB10A070000001001AF010A
PVH74QPM-RM-NS-11-CM7-31
PVH074R51AB10A070000002001AE010A
PVH74QIC2-RSM-1S-11-CM7-31
PVH057L52AA10B252000001001AA010A
PVH57C2-LF-2S-11-C25V-31
PVH131L02AF30B252000001002AA010A
PVH131C-LF-2D-11-C25V-31
PVH074R13AA10E252007001AF1AE010A
PVH74QIC-RAF-13S-11-C25VT7-31
PVH057R02AA10E252007001001AE010A
PVH57QIC-RF-2S-11-C25VT7-31
PVH074R01AA10B252000001001AN010A
PVH74C-RF-1S-11-C25V-31-115
PVH098R01AJ30A250000001001AN010A
PVH98C-RF-1S-11-C25-31-115
PVH057R02AA10A150000001AE2AA010A
PVH57C-RAF-2D-11-C15-31
PVH098R01AJ30D250005001001BC010A
PVH98QIC-RF-1S-11-C25T5-31-115
PVH098L02AJ30B102000AG1001AA010A
PVH98C-LF-2S-11-C10V-31
PVH074R02AA10A190000001AP2AA010A
PVH74C-RCF-2D-11-C19-31-036
PVH074R02AA10A190000001002AA010A
PVH74C-RF-2D-11-C19-31
PVH098L02AJ30A100000AG1001AA010A
PVH98C-LF-2S-11-C10-31
PVH074L02AA10A190000001002AA010A
PVH74C-LF-2D-11-C19-31
PVH098R02AJ30A250000001002AA010A
